Chinese RussianSpain


Home > News > Brief Introduction of Hookstrip Flat Screen and Mongoose PT Screen

Brief Introduction of Hookstrip Flat Screen and Mongoose PT Screen

Posted by:    Time:2014-12-09     click:

The Mongoose PT screen is constructed with two or three stainless steel layers bonded to a steel support plank.

Features of Hook Stripe Flat Plate Screen

1. Different layers with different density. To arrange these layers reasonably and exactly, the screening effect will become more and better. Screen with different mesh counts with suitable opening sizes of the backing plate. Doing so, Hook stripe flat plate screens will obtain the largest effective area under the condition of enough strength.

2. The bottom layer with low mesh counts has coarse wire and can be tight bonded to the backing to make up one block. So the strength of whole screen mesh get up and the useful life is increased

3. The meshes are divided into many independent small units by grids of the backing plate, can prevent rigs of tears from spreading overmuch. Accessory prepared rubber stoppers can be used to repair damages. By doing so, the operator can cut down the stop time and reduce the cost.

Mongoose PT screens are the only such units can fly like a solid feature with changes be adjusted. Mongoose PT screens provide you with an unprecedented ability to change the characteristics of the shaker movement and cuttings variation. Mongoose PT screens can switch from the simple flip of a linear elliptic motion and allow you to use a linear motion , and Diamond , high volume solids is usually encountered in a hole. This sometime interval requires producing high G force exciter effectively with the entire screen dense solid. Brandt shaker replace the typical flow lines, traps or possum belly and innovative distribution box of the Hook stripe flat plate screens . The unique design of the box redirect traffic uniformly distributed throughout the width of the screen, to increase liquid handling capability. Mongoose PT screens are based on the pre-tensioned screen adaptation, which can extend the life of the screen , while providing a dry solid, increase fluid recovery and overall lower operating costs.

Features and Benefits

Mongoose PT screen retention time and dry cuttings fast delivery and reload plus balanced elliptical motion - linear motion can flip the switch - did not stop vibrating screen shaker and thus change campaign function perfectly balanced basket of dry , light or heavy load linear or elliptical load balancing mode, thus can extend screen life steel basket to ensure uniform motion on the screen , to reduce fatigue and premature failure of beds wind insurance, unique distribution box replaced , providing higher capacity and rate of decay of the fluid from the flow stream line possum belly .

Featured Products: Derrick shaker | Mud gun

  • Label: